A : Adjust C : Clean I : Inspect (Clean, Adjust, Lubricate or replace if necessary) L : Lubricate R : Replace (#) - After first service, engine oil and engine oil filter replacement is a mandatory at every 12 months even the vehicle has not covered the specified kilometre. (**) - If any fastener found loose tighten to the specified torque.
S. NO.	DESCRIPTION	PERIODICAL MAINTENANCE (Whichever is earlier)
	Km (x1000)	0.5	5	10	15	20	25	30	35	40	45	50
	miles (x1000)	0.3	3	6	9	12	15	18	21	24	27	30
	Months	1.5	6	12	18	24	30	36	42	48	54	60
1	Engine Oil (#)	R		R		R		R		R		R
1	Engine Oil (#)	Check level at every 1000 km or earlier and top up as required
2	Engine Oil Filter (#)	R		R		R		R		R		R
3	Inlet and exhaust valve clearance			I		I		I		I		I
4	Spark Plug	I	I	I	I	R	I	I	I	R	I	I
5	HT Lead	I	I	I	I	I	I	I	I	I	I	I
6	Rubber hose, Air filter to throttle body	I	I	I	I	I	I	I	I	I	I	I
7	Rubber hose, Inlet manifold / Adapter	I	I	I	I	I	I	I	I	I	I	I
8	Evaporative emission equipment rubber hoses	I	I	I	I	I	I	I	I	I	I	I
9	Air filter element	C	C	R	C	R	C	R	C	R	C	R
9	Air filter element	Clean / Replace more frequently if operated in dusty condition
10	Vent pipe under air filter box	I	I	I	I	I	I	I	I	I	I	I
11	Throttle cable	A	A	A	A	A	A	A	A	A	A	A
12	Clutch cable / lever free play	Adjust every 1000 km or earlier as required
13	Clutch lever & front brake lever pivots	Lubricate every 1000 km or earlier as required
14	Brake pads - Front and Rear	I	I	I	I	I	I	I	I	I	I	I
15	Brake fluid - Front and Rear	I	I	I	I	R	I	I	I	R	I	I
16	Rear brake pedal and gear change pedal pivot	L	L	L	L	L	L	L	L	L	L	L
17	Brake hose and banjo bolt - Front and rear	I	I	I	I	I	I	I	I	I	I	I
18	Headstock bearings	I	I	I	I	I	I	I	I	I	I	I
19	Rear wheel drive chain	Clean, lubricate and adjust every 500 km or earlier as required or after riding in wet/dusty/muddy conditions
20	Rear wheel cush rubbers				I				I
21	Battery terminals (apply petroleum jelly)	I	I	I	I	I	I	I	I	I	I	I
22	Spokes tightness/wheel rim run out front and rear	I	I	I	I	I	I	I	I	I	I	I
23	Earth wire eyelet tightness			I		I		I		I		I
24	Tyre wear pattern front and rear	I	I	I	I	I	I	I	I	I	I	I
25	Side stand & center stand pivots	L	L	L	L	L	L	L	L	L	L	L
26	Rider and pillion footrest pivot	L	L	L	L	L	L	L	L	L	L	L
27	All mounting fasteners in vehicle for tightness**	I	I	I	I	I	I	I	I	I	I	I
NOTE -For maintenance after 50,000 km, please repeat the same frequency specified above, in consultation with a Royal Enfield Authorised Dealer / Service Centre.

Log in to your Royal Enfield account

Enter your email or mobile number

Enter your OTP

New to royalenfield.com?

Or sign in via

Mobile OTP Verification

Select Region

GLOBAL

ASIA PACIFIC

EUROPE

AMERICAS

MIDDLE EAST & AFRICA

Select Country

Note

Classic 650

Book a Test Ride

Find a Store

Book a Test Ride

Find a Store