Royal Enfield Royal Enfield Royal Enfield Royal Enfield Royal Enfield
Select Country

Select Region

Select Country

Note

We use our own cookies for the use of the site, personalize content and ads and to perform analyses of our traffic. We also share information about your use of our site with analytics partners who may combine it with other information that you’ve provided to them or that they’ve collected from your use of their services. If you want to learn more about cookies and opt-out, click the button Privacy and Cookie Policy. If you choose not to agree to the use of cookies all features of the site may not operate as intended.

S. NO.DESCRIPTIONPERIODICAL MAINTENANCE (Whichever is earlier)
 Km (x1000)0.55101520253035404550
 miles (x1000)0.336912151821242730
 Months1.56121824303642485460
1Engine Oil (#)R R R R R R
Check level at every 1000 km or earlier and top up as required
2Engine Oil Filter(#)R R R R R R
3Inlet and exhaust valve clearance  I I I I I
4Spark PlugIIIIRIIIRII
5HT LeadIIIIIIIIIII
6Rubber hose, Air filter to throttle bodyIIIIIIIIIII
7Rubber hose, Inlet manifold / AdapterIIIIIIIIIII
8Evaporative emission equipment rubber hosesIIIIIIIIIII
9Fuel filter external    R   R  
10Air filter elementCCRCRCRCRCR
Clean / Replace more frequently if operated in dusty condition
11Vent pipe under air filter boxIIIIIIIIIII
12Accelerator and throttle pulley cables free playAAAAAAAAAAA
13Clutch cable / lever free playAdjust every 1000 km or earlier as required
14Hand levers pivot pointLubricate every 1000 km or earlier as required
15Brake pads - Front and RearIIIIIIIIIII
16Disc brake fluid level - Front and RearIIIIRIIIRII
17Rear brake pedal and gear change pedal pivotLLLLLLLLLLL
18Brake hose and banjo bolt - Front and rearIIIIIIIIIII
19Headstock bearingsIIIIIIIIIII
20Rear wheel drive chainLubricate and adjust every 1000 km/clean, lubricate and adjust
every service or earlier as required
21Rear wheel cush rubbers   I   I   
22Spokes tightness/wheel rim run out front and rear
(It is applicable for spokes wheel model)		IIIIIIIIIII
23Battery terminals (apply petroleum jelly)IIIIIIIIIII
24Earth wire eyelet tightness  I I I I I
25Tyre wear pattern front and rearIIIIIIIIIII
26Pivot-side standLLLLLLLLLLL
27Rider and pillion footrest pivotLLLLLLLLLLL
28All mounting fasteners in vehicle for tightness**IIIIIIIIIII

A : Adjust C : Clean I : Inspect (Clean, Adjust, Lubricate or replace if necessary) L : Lubricate R : Replace

(#) - After first service, engine oil and engine oil filter replacement is a mandatory at every 12 months even the vehicle has not covered the specified kilometre.

(**) - If any fastener found loose tighten to the specified torque.

NOTE -For maintenance after 50,000 km, please repeat the same frequency specified above, in consultation with a Royal Enfield

Authorised Dealer / Service Centre.

Close