Royal Enfield Royal Enfield Royal Enfield Royal Enfield Royal Enfield

Select Country

Note

We use our own cookies for the use of the site, personalize content and ads and to perform analyses of our traffic. We also share information about your use of our site with analytics partners who may combine it with other information that you’ve provided to them or that they’ve collected from your use of their services. If you want to learn more about cookies and opt-out, click the button Privacy and Cookie Policy. If you choose not to agree to the use of cookies all features of the site may not operate as intended.

S. NO. DESCRIPTION PERIODICAL MAINTENANCE (Whichever is earlier)
  Km (x1000) 0.5 5 10 15 20 25 30 35 40 45 50
  Months 1.5 6 12 18 24 30 36 42 48 54 60
1 Engine Oil (Level check/replace) R   R   R   R   R   R
Check level at every 1,000 km or earlier and top up as required
2 Engine oil filter element R   R   R   R   R   R
3 Engine oil strainer on crankcase LH C   C   C   C   C   C
4 Inlet/exhaust tappet setting     I&A   I&A   I&A   I&A   I&A
5 Rubber hose-intake adapter I I I I I I I I I I I
6 Evaporative emission equipment rubber hoses & drain the overfilled by removing plug  I I I I I I I I R I I
7 Spark plug     C&A   R   C&A   R   C&A
8 HT lead for crack I I I I I I I I I I I
9 Air filter element C C R C R C R C R C R
Clean / Replace more frequently if operated in dusty condition
10 Vent pipe under air filter box I I I I I I I I I I I
11 Starter motor & starter relay connection I I I I I I I I I I I
12 Battery terminals (apply petroleum jelly) C C C C C C C C C C C
13 Earth wire eyelet contact         I           I
14 Injector Horse I I I I I I I I I I I
15 Fuel filter in fuel pump             R        
16 Front fork oil (For both endurance and gabriel)         R       R    
17 Steering ball races play Inspect & adjust, if required lubricate for every 5,000 every service or earlier as required
18 Spokes tightness/wheel rim run out front & rear I I I I I I I I I I I
19 Swing arm pivot bush & spacer I Inspect & if required lubricate for every 5,000 km or earlier as required. Replace if necessary
20 Tire wear pattern (front & rear) I I I I I I I I I I I
21 Rear wheel drive chain Clean, lubricate every 1,000 km / clean, lubricate & adjust every 5,000 km or earlier as required
22 Rear wheel cush drive rubbers         I&R       I&R    
23 Front & rear brake hose & banjo bolt I I I I I I I I I I I
24 Brake fluid level, front & rear disc I I I I R I I I R I I
25 Clutch lever / cable free play Adjust every 1,000 km or earlier as required & replace if required
26 Hand levers & foot levers Lubricate every 1,000 km or earlier as required.
27 Pivot side stand, center stand, pillion foot rest, gear shifter, brake pedal, levers** L L L L L L L L L L L
28 Throttle cable Adjust every 5,000 km or earlier if required
29 Brake pads - front & rear I I I I I I I I I I I
30 Side stand switch operation I I I I I I I I I I I
31 All mounting fasteners in vehicle for tightness I I I I I I I I I I I
32 Throttle body - cleaning Throttle body should be removed from the vehicle and cleaned with a dry microfibre cloth, usage of throttle body cleaners or any similar solvent or alcohol based liquids for cleaning is strictly prohibited, Throttle body cleaning every 10,000 km / 12 months or earlier as required..

A : Adjust C : Clean I : Inspect (Clean, Adjust, Lubricate or replace if necessary) L : Lubricate R : Replace

(#) - After first service, engine oil and engine oil filter replacement is a mandatory at every 12 months even the vehicle has not covered the specified kilometre.

(**) - If any fastener found loose tighten to the specified torque.

NOTE -For maintenance after 50,000 km, please repeat the same frequency specified above, in consultation with a Royal Enfield

Authorised Dealer / Service Centre.

Close