| S. NO. | DESCRIPTION | PERIODICAL MAINTENANCE (Whichever is earlier) | ||||||||||
|---|---|---|---|---|---|---|---|---|---|---|---|---|
| Km (x1000) | 0.5 | 7.5 | 15 | 22.5 | 30 | 37.5 | ||||||
| miles (x1000) | 0.3 | 4.66 | 9.32 | 13.98 | 18.64 | 23.3 | ||||||
| Months | 1.5 | 12 | 24 | 36 | 248 | 60 | ||||||
| 1 | Engine Oil (#) | R | R | R | R | R | R | |||||
| Check level at every 1000 km or earlier and top up as required | ||||||||||||
| 2 | Engine Oil Filter (#) | R | R | R | R | R | R | |||||
| 3 | Inlet and exhaust valve clearance | I | I | I | I | I | ||||||
| 4 | Spark Plug | I | I | R | I | R | I | |||||
| 5 | HT Lead | I | I | I | I | I | I | |||||
| 6 | Rubber hose, Air filter to throttle body | I | I | I | I | I | I | |||||
| 7 | Rubber hose, Inlet manifold / Adapter | I | I | I | I | I | I | |||||
| 8 | Evaporative emission equipment rubber hoses | I | I | I | I | I | I | |||||
| 9 | Fuel filter external | R | R | |||||||||
| 10 | Air filter element | C | R | R | R | R | R | |||||
| Clean / Replace more frequently if operated in dusty condition | ||||||||||||
| 11 | Vent pipe under air filter box | I | I | I | I | I | I | |||||
| 12 | Accelerator and throttle pulley cables free play | A | A | A | A | A | A | |||||
| 13 | Clutch cable / lever free play | Adjust every 1000 km or earlier as required | ||||||||||
| 14 | Hand levers pivot point | Lubricate every 1000 km or earlier as required | ||||||||||
| 15 | Brake pads - Front and Rear | I | I | I | I | I | I | |||||
| 16 | Disc brake fluid level - Front and Rear | I | I | R | I | R | I | |||||
| 17 | Rear brake pedal and gear change pedal pivot | L | L | L | L | L | L | |||||
| 18 | Brake hose and banjo bolt - Front and rear | I | I | I | I | I | I | |||||
| 19 | Headstock bearings | I | I | I | I | I | I | |||||
| 20 | Rear wheel drive chain | Lubricate and adjust every 1000 km/clean, lubricate and adjust every service or earlier as required | ||||||||||
| 21 | Rear wheel cush rubbers | I | I | |||||||||
| 22 | Spokes tightness/wheel rim run out front and rear (It is applicable for spokes wheel model) | I | I | I | I | I | I | |||||
| 23 | Battery terminals (apply petroleum jelly) | I | I | I | I | I | I | |||||
| 24 | Earth wire eyelet tightness | I | I | I | I | I | ||||||
| 25 | Tyre wear pattern front and rear | I | I | I | I | I | I | |||||
| 26 | Pivot-side stand | L | L | L | L | L | L | |||||
| 27 | Rider and pillion footrest pivot | L | L | L | L | L | L | |||||
| 28 | All mounting fasteners in vehicle for tightness** | I | I | I | I | I | I | |||||
A : Adjust C : Clean I : Inspect (Clean, Adjust, Lubricate or replace if necessary) L : Lubricate R : Replace (#) - After first service, engine oil and engine oil filter replacement is a mandatory at every 12 months even the vehicle has not covered the specified kilometre. (**) - If any fastener found loose tighten to the specified torque. | ||||||||||||
NOTE -For maintenance after 37,500 km, please repeat the same frequency specified above, in consultation with a Royal Enfield Authorised Dealer / Service Centre. | ||||||||||||
